SHERWIN-WILLIAMS DIVERSIFIED BRANDS, INC -- S00204, DRY GRAPHITE LUBE, LUBRICANTS, (SUP DAT) -- -
<pre>===================== Product Identification =====================
Product ID:S00204, DRY GRAPHITE LUBE, LUBRICANTS, (SUP DAT)
MSDS Date:08/17/1998
FSC:NIIN:Submitter:N EN
Status Code:A
=== Responsible Party ===
Company Name:SHERWIN-WILLIAMS DIVERSIFIED BRANDS, INC
Address:31500 SOLON RD
City:SOLON
State:OH
ZIP:44139
Country:US
Info Phone Num:800-777-2966
Emergency Phone Num:216-566-2917
Resp. Party Other MSDS Num.:LUBE2/ISD
CAGE:09800
=== Contractor Identification ===
Company Name:SHERWIN-WILLIAMS DIVERSIFIED BRANDS, INC.
Address:26300 FARGO AVENUE
Box:City:BEDFORD HEIGHTS
State:OH
ZIP:44146
Country:US
Phone:216-292-7400 OR 216-595-8634
CAGE:09800
============= Composition/Information on Ingredients =============
Ingred Name:PROPANE. (VAPOR PRESSURE 760.0 MM HG)
CAS:74-98-6
RTECS #:TX2275000
= Wt:15.
OSHA PEL:1000 PPM
Ingred Name:BUTANE. (VAPOR PRESSURE 760.0 MM HG)
CAS:106-97-8
RTECS #:EJ4200000
= Wt:14.
OSHA PEL:800 PPM
ACGIH TLV:800 PPM
Ingred Name:HEPTANE. (VAPOR PRESSURE 50.0 MM HG)
CAS:142-82-5
RTECS #:MI7700000
= Wt:45.
OSHA PEL:400 PPM
OSHA STEL:500 PPM
ACGIH TLV:400 PPM
ACGIH STEL:500 PPM
Ingred Name:2-PROPANOL. (VAPOR PRESSURE 33.0 MM HG)
CAS:67-63-0
RTECS #:NT8050000
= Wt:24.
OSHA PEL:400 PPM
OSHA STEL:500 PPM
ACGIH TLV:400 PPM
ACGIH STEL:500 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EXPOSURE MAY BE BY INHALATION
AND/OR SKIN OR EYE CONTACT, DEPENDING ON CONDITIONS OF USE. TO
MINIMIZE EXPOSURE, FOLLOW RECOMMENDATIONS FOR PROPER USE,
VENTILATION, AND PERSONAL PROTECTIVE EQUIP MENT. EFFECTS OF
EXPOSURE: IRRITATION OF EYES, SKIN AND RESPIRATORY SYSTEM. MAY
CAUSE NERVOUS SYSTEM DEPRESSION. EXTREME OVEREXPOSURE MAY RESULT IN
UNCONSCIOUSNESS AND POSSIBLY DEATH. SIGNS AND SYMPTO MS OF
OVEREXPOSURE: HEADACHE, DIZZINESS, NAUSEA, AND LOSS OF COORDINATION
ARE INDICATIONS OF EXCESSIVE EXPOSURE TO VAPORS OR SPRAY MISTS.
REDNESS AND ITCHING OR BURNING SENSATION MAY INDICATE EYE OR E
XCESSIVE SKIN EXPOSURE.(EFTS OF OVEREXP)
Effects of Overexposure:HEALTH HAZARDS (CONT):CHRONIC HEALTH HAZARDS:
PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE ADVERSE EFFECTS TO
LIVER, URINARY AND CARDIOVASCULAR SYSTEMS. REPORTS HAVE ASSOCIATED
REPEATED AND PROLONGED OVEREXPOSURE TO SOLVENTS WITH PERMANENT
BRAIN AND NERVOUS SYSTEM DAMAGE.
Medical Cond Aggravated by Exposure:CARDIOVASCULAR PROBLEMS MAY BE
AGGRAVATED BY OVEREXPOSURE TO METHYLENE CHLORIDE.
======================= First Aid Measures =======================
First Aid:INHAL: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE BREATHING.
KEEP WARM AND QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY W/SOAP &
WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE RE-USE.
EYES: FLUS H WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES.
GET MEDICAL ATTENTION. INGEST: GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:=-28.9C, -20.F
Lower Limits:1.0%
Upper Limits:12.8%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . WATER SPRAY MAY BE INEFTIVE. IF WATER IS USED, FOGG
NOZZLES ARE PREFERABLE. WATER MAY BE USED TO COOL CLSD CNTNRS TO
PVNT PRESS BUILD UP & POSS AUTOIGNIT OR EXPLOSION WHEN EXPOSED TO
EXTREME HEAT.
Unusual Fire/Explosion Hazard:CLSD CNTNRS MAY EXPLODE (DUE TO BUILD-UP
OF PRESS) WHEN EXPOSED TO EXTREME HEAT. ISOLATE FROM HEAT, ELEC
EQUIP, SPKS & OPEN FLAME. APPLICATION TO HOT SURFS REQS SPECIAL
PRECAUTIONS. DURING EMER CNDTNS OVEREXP TO DECOMP PRODS MAY CAUSE
HLTH HAZ. SYMPS MAY NOT BE IMMED APPARENT. OBTAIN MED ATTN.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
====================== Handling and Storage ======================
Handling and Storage Precautions:CONTENTS ARE EXTREMELY FLAMM. KEEP
AWAY FROM HEAT, SPKS, & OPEN FLAME. VAPS WILL ACCUM READILY & MAY
IGNITE EXPLO. DURING USE & UNTIL ALL VAPS ARE GONE: KEEP AREA
VENTILATED-DO NOT SMOKE-EXTING ALL FL AMES, PILOT LIGHT, &
HEATERS-TURN OFF STOVES, ELEC TOOLS & APPLIANCES, & ANY OTHER
SOURCES OF IGNIT.
Other Precautions:CONSULT NFPA CODE. USE APPRVD BONDING & GROUNDING
PROCEDURES. CONTENTS UNDER PRESS. DO NOT PUNCTURE, INCIN/EXPOSE TO
TEMP ABOVE 120F. HEAT FROM SUNLIGHT, RADIATORS, STOVES, HOT WATER,
& OTHER HEAT SOU RCES COULD CAUSE CNTNR TO BURST. DO NOT TAKE
INTERNALLY. KEEP OUT OF REACH OF CHILDREN. (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENT, WEAR A PROPERLY FITTED ORGANIC
VAPOR/PARTICULATE RESP APPRVD BY NIOSH FOR PROTECTION AGAINST
MATERIALS IN INGREDIENTS.
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPTABLE IF EXPOS TO MATLS IN
INGRED SECTION IS MAINTAINED BELOW APPLIC EXPOS LIMITS. REFER TO
OSHA STDS (SUPDAT)
Protective Gloves:IMERVIOUS GLOVES .
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA . USE W/ADEQ VENT. AVOID BRTHG VAP & SPRAY MIST. AVOID
CONT W/SKIN & EYES.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
MFR TRADE NAME/PART NO: RUST PREVENTATIVES & MAINTENANCE PRODS - 2.
WEIGHT PER GAL 5.51 LBS. VOC (VOLATILE ORGANIC COMPOUNDS)
TOTAL-LBS/GAL: 5.43. VOC AS PERCENT BY WEIGHT PER BAAQMD RULE 49:
98.5. O THER PREC: INTENTIONAL MISUSE BY DELIB CONC & INHALING
CONTENTS CAN BE HARMFUL/FATAL. VENT:1910.94, 1910.107, 1910.108.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:< 0 - 701 F
Vapor Pres:SEE INGREDIENTS
Vapor Density:HVR/AIR
Spec Gravity:0.65 - 1.06
Evaporation Rate & Reference:FASTER THAN ETHER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF METALS LISTED IN INGREDIENT SECTION II.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM PRODUCTS MAY BE HAZARDOUS AS DEFINED
UNDER RESOURCE CONSERVATION & RECOVERY ACT 40 CFR 261. WASTE MUST
BE TESTED FOR IGNITABILITY TO DETERM APPLIC RPA HAZ WASTE NUMBERS.
DO NOT INCIN. DEPRE SSURIZE CNTNR. DISPOSE OF I/A/W FEDERAL, STATE,
& LOCAL REGS REGARDING POLLUTION.
===================== Regulatory Information =====================
SARA Title III Information:DOES NOT CONTAIN ANY INGREDIENTS SUBJECT TO
THE REPORTING REQUIREMENTS OF THE SUPERFUND AMENDMENTS AND
REAUTHORIZATION ACT (SARA) SECTION 313, 40 CFR 372.65 C.
Federal Regulatory Information:ALL CHEMICALS IN THESE PRODUCTS ARE
LISTED, OR ARE EXEMPT FROM LISTING, ON THE TSCA INVENTORY.
State Regulatory Information:WARNING: THIS PRODUCT CONTAINS CHEMICALS
KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER, AND BIRTH DEFECTS
AND OTHER REPRODUCTIVE HARM.
======================= Other Information =======================
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.